Homeowner's Installation andOperating ManualINSTALLER: DO NOT DISCARD THIS MANUAL - LEAVE FOR HOMEOWNERDirect VentModel: DVRT41DO NOT STORE OR U
10DVRT41 Direct Vent Gas Fireplace10006740FP1031Fig. 13 Completed conversion.After conversion to top vent configura-tion, the 4” (102mm) flue pipe sho
11DVRT41Direct Vent Gas Fireplace10006740VVVVVVVXXXDEBBBCBMBAJKFLVENT TERMINATION AIR SUPPLY INLETAREA WHERE TERMINAL IS NOT PERMITTEDHIFixedClosedFi
12DVRT41 Direct Vent Gas Fireplace10006740Outside CornerInside CornerTermination ClearancesTermination clearances for buildings with combustible and n
13DVRT41Direct Vent Gas Fireplace10006740Male EndFemaleEndScrew HolesTWL100Fig. 17 Twist-Lock pipe joints.Twist Lock PipesWhen using twist lock pipe
14DVRT41 Direct Vent Gas Fireplace10006740Rear Wall Vent InstallationStep 1Locate and cut the vent opening in the wall. For com-bustible walls first f
15DVRT41Direct Vent Gas Fireplace10006740FinishedWallVentTerminationFig. 23 Side view of final unit location.FP1005Vertical Sidewall ApplicationSince
16DVRT41 Direct Vent Gas Fireplace10006740In Figure 28 & 29, dimension A plus B must not begreater than 17’ (5.2m)• The maximum number of 45° elbo
17DVRT41Direct Vent Gas Fireplace10006740XXFP1181Fig. 33 Vertical height requirements.Vertical Sidewall InstallationTwist Lock PipeStep 1Locate vent
18DVRT41 Direct Vent Gas Fireplace10006740Sealing vent pipe and firestop gaps with hightemperature sealant will restrict cold air beingdrawn in around
19DVRT41Direct Vent Gas Fireplace10006740Below Grade InstallationWhen it is not possible to meet the required ventterminal clearances of 12” (305mm) a
2DVRT41 Direct Vent Gas Fireplace10006740Installation & Operating Instructions ...
20DVRT41 Direct Vent Gas Fireplace10006740Vertical Through-the-Roof Installation1. Locate your fireplace.2. Plumb to center of the (4”) flue collar fr
21DVRT41Direct Vent Gas Fireplace10006740Typical RoofSupportApplicationTypical CeilingSupportApplicationFig. 42 Venting supports.FP11843 #5 Sheet Met
22DVRT41 Direct Vent Gas Fireplace100067407TDVRVT - Through the wall Rear Vent TerminationStarter Kit -Model 7TDVSK - Sidewall Venting (Twist Lock Pip
23DVRT41Direct Vent Gas Fireplace10006740Glass InformationOnly glass approved by CFM SpecialtyHome Products should be used on thisfireplace.• The use
24DVRT41 Direct Vent Gas Fireplace10006740Installation of LogsRemove front glass. (Refer to "Window Frame Assem-bly Removal" Section, Fig. 4
25DVRT41Direct Vent Gas Fireplace10006740Flame CharacteristicsIt is important to periodically perform a visual check ofthe pilot and the burner flames
26DVRT41 Direct Vent Gas Fireplace100067403. Open louvre assembly bottom.4. Push in gas control knob slightly and turnclockwise to "OFF".
27DVRT41Direct Vent Gas Fireplace10006740Lighting & Operating InstructionsFor Fireplaces equipped with SIT822 Gas Valve (EN or EP)A. This fireplac
28DVRT41 Direct Vent Gas Fireplace10006740Instructions for RF Comfort Control ValveThe Comfort Control Valve allows remote control oftemperature, fan
29DVRT41Direct Vent Gas Fireplace10006740Delay Timer ModeThe shut off delay timer has a maximum of 2 hours anda minimum of zero minutes. To change the
3DVRT41Direct Vent Gas Fireplace10006740A)Flat on wall B)Cross corner C) **IslandD)*Room divider E)*Flat on wall corner F) Chase installationY) 6"
30DVRT41 Direct Vent Gas Fireplace10006740LED Count Service Action8 Replace valve7 Confirm stepper motor connectionexists5 Confirm fan connection exis
31DVRT41Direct Vent Gas Fireplace10006740Light pilot burnerSet manual switchto local or remoteRelease pilotstatknobTurn pilotstat knobfrom PILOT to ON
32DVRT41 Direct Vent Gas Fireplace10006740Window Frame Assembly to be Removed Before Service WorkTroubleshooting – Honeywell VS8421START CHECKGas Supp
33DVRT41Direct Vent Gas Fireplace10006740WARNING: Before doing any gas control service work, remove glass front.SYMPTOM POSSIBLE CAUSES CORRECTIVE AC
34DVRT41 Direct Vent Gas Fireplace10006740SIT 822 Valve with a Honeywell Electronic IgniterTroubleshooting the Gas Control SystemSTART•TURN GAS SUPPLY
35DVRT41Direct Vent Gas Fireplace10006740Fuel Conversion InstructionsTo convert the DV360/580 units for use with a differentgas follow these instructi
36DVRT41 Direct Vent Gas Fireplace10006740Fuel Conversion InstructionsHoneywell Comfort Control Valve ONLYWARNING: The conversion must only beundertak
37DVRT41Direct Vent Gas Fireplace10006740LOCALCenterPlungerBlue -NGRed - LPMotor Top CapFP1037bFig. 65 Depressd and turn center plunger.Fig. 67 Burn
38DVRT41 Direct Vent Gas Fireplace10006740Burner and Burner CompartmentIt is important to keep the burner and the burnercompartment clean. At least on
39DVRT41Direct Vent Gas Fireplace1000674023456a,b789a9b9e9c9d10111213141516172223PILOTONOFFPILOTADJLOHITPTHTHTP24a,b25a,b26a,b302732282933HILO31a,b34a
4DVRT41 Direct Vent Gas Fireplace10006740Ref. DVRT41A 41” (1041mm)B 37” (940mm)C 36” (914mm)D24¹⁄₂” (622mm)E7”(178mm)F6”(152mm)G1¹⁄₄” (32mm)H19¹⁄₂” (4
40DVRT41 Direct Vent Gas Fireplace10006740DVRT41 (continued)Ref. Description DVRT411. Log Set DVRT41 (Complete) 100061851a. Log Rear (G7) 100067981b.
41DVRT41Direct Vent Gas Fireplace10006740DVRT41 (continued)Ref. Description DVRT4130. Thermocouple - RN/RP 5337331a. Valve - SIT 822 - EN 5788431b. Va
42DVRT41 Direct Vent Gas Fireplace10006740Fuel Conversion KitsNatural Gas to LPDVRT41RN/EN Kit #10006826DVRT41RFN Kit #10006827LP to Natural GasDVRT41
43DVRT41Direct Vent Gas Fireplace10006740Optional Accessories AvailableFK12 Fan Assembly1. Open louvre assembly bottom.2. Install FK12 fan in back of
44DVRT41 Direct Vent Gas Fireplace10006740Remote ControlsOptional remote control units are available to controldifferent functions of the appliance.Mo
45DVRT41Direct Vent Gas Fireplace10006740This appliance may be installed as an OEM installation in a manufactured home (US only), or a mobilehome; it
46DVRT41 Direct Vent Gas Fireplace100067408. Remove the compression fitting which holds thealuminium tubing in the pilot assembly. This willreveal the
47DVRT41Direct Vent Gas Fireplace10006740BASIC WARRANTYCFM Specialty Home Products (hereinafter referred to collectively asthe Company) warrants that
Efficiency RatingsModel EnerGuide Ratings Steady State (%) D.O.E.Fireplace Efficiency (%) Fan-OFF Fan-ON (AFUE%)DVRT41RN 64 83 84 64DVRT41RP 64 84 85
5DVRT41Direct Vent Gas Fireplace10006740Fireplace Dimensions (Installed as Rear Vent)HR - Rough Opening WidthGas LineAccessRoughOpeningHeightElectrica
6DVRT41 Direct Vent Gas Fireplace10006740MantelsThe height that a combustible mantel is fitted abovethe fireplace is dependent on the depth of the man
7DVRT41Direct Vent Gas Fireplace10006740Framing And FinishingCheck fireplace to make sure it is lev-elled and properly positioned.To mount the applian
8DVRT41 Direct Vent Gas Fireplace10006740Remote ON/OFF Switch InstallationDo not wire the remote ON/OFF wallswitch for this gas appliance into a 120vp
9DVRT41Direct Vent Gas Fireplace10006740The EB-1 electrical junction box has been suppliedstandard on the DV360/580 models to allow for theeasy instal
Comments to this Manuals