Vermont Casting DVT38S2IN User Manual

Installation Instructions and Homeowner’s ManualWARNING! IF THE INFORMATION IN THIS MANUAL IS NOT FOLLOWED EXACTLY, A FIRE OR EXPLOSION MAY RESULT CAU

10Chateau™ Direct Vent Gas Fireplace20011957Remote Control TransmitterOperating InstructionsIntroductionThis transmitter operating range is approximat

11Chateau™ Direct Vent Gas Fireplace20011957FP1820F-C display9/07Screen while de-pressing ON keyScreen while de

12Chateau™ Direct Vent Gas Fireplace20011957FP1821set temp9/07To Change the Set TemperaturePress and hold t

13Chateau™ Direct Vent Gas Fireplace20011957Operational Notes:The Thermostatic feature on the transmitter operates the appliance whenever the ROOM TEM

14Chateau™ Direct Vent Gas Fireplace20011957General VentingYour fireplace is approved to be vented either through the side wall, or vertical through th

15Chateau™ Direct Vent Gas Fireplace20011957VVVVVVVXXXDEBBBCBMBAJKFLVENT TERMINATION AIR SUPPLY INLETAREA WHERE TERMINAL IS NOT PERMITTEDHI

16Chateau™ Direct Vent Gas Fireplace20011957Outside CornerInside CornerTermination ClearancesTermination clearances for buildings with combustible and

17Chateau™ Direct Vent Gas Fireplace20011957Horizontal TerminationThe vent must rise vertically a minimum of 24” (610 mm) off the top of the u

18Chateau™ Direct Vent Gas Fireplace20011957When the vent termination exits through foundations less than 20” (508mm) below siding outcrop, the vent p

19Chateau™ Direct Vent Gas Fireplace20011957STEP 2Measure wall thickness and cut zero clearance sleeve parts to proper length (MAXIMUM 12”/305 mm). As

2Chateau™ Direct Vent Gas Fireplace20011957Please read the installation & operating instructions before using this appliance.Thank you and congrat

20Chateau™ Direct Vent Gas Fireplace20011957FP1458Fig. 22 Through the wall.FP1457Fig. 21 Horizontal length requirement.XFP1460Fig. 23 Secure termi

21Chateau™ Direct Vent Gas Fireplace20011957FP1461thru wall trim3/17/04 djt2” (51mm)1” (25mm)Min.1” (25mm) Min.16¹⁄₄” x 16¹⁄₄”(413 x 413mm) OpeningF

22Chateau™ Direct Vent Gas Fireplace20011957Vertical Through-the-Roof ApplicationsUse of Restrictor Plate for Vertical Venting ApplicationThe primary

23Chateau™ Direct Vent Gas Fireplace20011957plicable. When using the unitized 30°, 45° or 90° elbows, apply 1/4” bead of high temperature, 550°F or hi

24Chateau™ Direct Vent Gas Fireplace20011957This Gas Fireplace has been approved for,• Vertical installations up to 40’ (12 m) in height. Up to a 20’

25Chateau™ Direct Vent Gas Fireplace20011957FP593SR/C11/20/97Attic InstallationCeiling InstallationNails (4)Firestop SpacerJoistJoistFirestop SpacerNa

26Chateau™ Direct Vent Gas Fireplace20011957Chimney Components Horizontal Starter Kit Contains 24”-40” telescopic pipe* for minimum vertical SK

27Chateau™ Direct Vent Gas Fireplace20011957Only glass approved by CFM Corporation should be used on this fireplace.1. Turn the fireplace OFF (includin

28Chateau™ Direct Vent Gas Fireplace20011957firebox. Tilt it carefully toward the side until the piece is in place. Using the two (2) brackets and four

29Chateau™ Direct Vent Gas Fireplace200119571. Ensure the four (4) screws that attach the fettle to the burner are secure.2. Set the andirons in pla

3Chateau™ Direct Vent Gas Fireplace20011957This gas fireplace should be installed by a qualified installer, preferably NFI or WETT (Canada) certified, in

30Chateau™ Direct Vent Gas Fireplace200119576. Position the log burner overlay. (Fig. 45) The overlay is very fragile and must be handled with extra c

31Chateau™ Direct Vent Gas Fireplace20011957Log Right Grate (F49)Figure 48LG50410. Position the log right grate. (Fig. 48) Hold th

32Chateau™ Direct Vent Gas Fireplace20011957It is important to periodically perform a visual check of the pilot and burner flames. Compare them to Figu

33Chateau™ Direct Vent Gas Fireplace20011957Trim InstallationCAUTION: Allow fireplace to cool if it has been in operation.Trim comp

34Chateau™ Direct Vent Gas Fireplace20011957Lighting & Operating InstructionsFor Fireplaces equipped with American Flame Automatic Control System

35Chateau™ Direct Vent Gas Fireplace20011957TroubleshootingIf erratic system behavior is observed that cannot be resolved by the methods outlined belo

36Chateau™ Direct Vent Gas Fireplace20011957Troubleshooting American Flame Gas Control System (continued)Main flame will not light• Verify the gas sup

37Chateau™ Direct Vent Gas Fireplace20011957American Flame Gas Control System Error CodesIgnition Safety: Protection for Ignition SystemError Code: On

38Chateau™ Direct Vent Gas Fireplace20011957Fuel Conversion InstructionsWARNING! This conversion kit shall be installed by a qualified service ag

39Chateau™ Direct Vent Gas Fireplace20011957CO134AF pilot orifice3/07Index TabSnap RingAllen WrenchCO134Fig. 56 Remove pilot orifice.1. Remove two (2

4Chateau™ Direct Vent Gas Fireplace20011957YDABCEYXLU584Locating unitDVT38S23/17/04 djtLocating Your FireplaceLU584-1Fig. 2 Locate gas fireplace.A)

40Chateau™ Direct Vent Gas Fireplace2001195722. Turn on gas supply and operate valve with remote control as needed to indicate gas pressure. The mani

41Chateau™ Direct Vent Gas Fireplace20011957MaintenanceBurner and Burner CompartmentIt is important to keep the burner and the burner compartment clea

42Chateau™ Direct Vent Gas Fireplace20011957CFM Corporation reserves the right to make changes in design, materials, specifications, prices and discont

43Chateau™ Direct Vent Gas Fireplace20011957DVT38S2 (continued) Ref. Description DVT38S2 1. Log Set (Complete) 20011955 1a. Log Overlay F56 2

44Chateau™ Direct Vent Gas Fireplace20011957DVT38S2 (continued) Ref. Description DVT38S2 26. Trim Kit Complete (2 per fireplace) 20010894 26a.

45Chateau™ Direct Vent Gas Fireplace20011957AccessoriesBack-up Battery KitAll Models: DVTBBKFollow instructions provided with the kit and on Page 8 fo

46Chateau™ Direct Vent Gas Fireplace20011957

47Chateau™ Direct Vent Gas Fireplace20011957LIMITED LIFETIME WARRANTY CFM Corporation (hereinafter referred to as CFM) warrants that all cast iron pa

Efficiency Ratings Model EnerGuide Ratings Fireplace Efficiency (%) DVT38S2IN 47.1 DVT38S2IP 47.1410 Admiral Blvd. • Mississauga, Ontario, Cana

5Chateau™ Direct Vent Gas Fireplace20011957Top of Unit to Ceiling ... 36” (914 mm)Front of Unit to Combustibles (both sid

6Chateau™ Direct Vent Gas Fireplace20011957A hearth is not mandatory but is recommended for aesthetic purposes. We recommend a noncombustible hearth

7Chateau™ Direct Vent Gas Fireplace20011957Gas Inlet and Manifold Pressures Natural LP (Propane) Minimum Inlet Pressure 5.5” w.c. 11.0” w.c. M

8Chateau™ Direct Vent Gas Fireplace20011957Control SystemThe gas control system is located on the right hand side of the firebox behind an access panel

9Chateau™ Direct Vent Gas Fireplace20011957PilotMainAF-4000DC MotorRedBlackWhite or GreenGreen or WhiteOrange or WhiteBlackBrownRedOrangeMainModuleBla